Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Need help with transfer case install
#1
I'm having a tough time getting my transfer case bolted back onto my transmission. I've never tried this before so I'm learning as I go with this one.. :banghead:

[YOUTUBE]<object width="640" height="385"><param name="movie" value="http://www.youtube.com/v/iM9nNYctqfY&amp;hl=en_US&amp;fs=1"></param><param name="allowFullScreen" value="true"></param><param name="allowscriptaccess" value="always"></param><embed src="http://www.youtube.com/v/iM9nNYctqfY&amp;hl=en_US&amp;fs=1" type="application/x-shockwave-flash" allowscriptaccess="always" allowfullscreen="true" width="640" height="385"></embed></object>[/YOUTUBE]
[SIGPIC][/SIGPIC]
Reply
#2
if your trans is out, bring it over and i'll bolt them together for you.
East Coast Surplus & Tactical
336-674-3868
Reply
#3
I separated the transmission and was able to get it bolted up. I now have two pieces to bolt to the transmission, the transfer case and that section that sits between the transfer case and the transmission. Should I try to separate the transfer case from the section that sits between it and the transmission or is it possible to get them attached to the transmission when it's installed?
[SIGPIC][/SIGPIC]
Reply
#4
you can do it either way but it might be easier one at a time. thats how i did it and it slid together good.
Life is short------drive your bronco everyday!
Reply
#5
be careful if you separate the adapter. I think there is a bearing that the balls will fall out on you if you're not careful. That may be a different combo - not positive.
'74 Grocery Getter, '73 Project Buggy, '77 Parts Rig

[Image: Bannerpic.jpg]
Reply
#6
Just watched the video - is that as far as you can get it on? Have you tried lowering the rear of the case? If you get it close but it's still giving trouble that last 1/2 inch don't use the bolts to pull it together - it'll only crack the cast housing. Good Luck.
'74 Grocery Getter, '73 Project Buggy, '77 Parts Rig

[Image: Bannerpic.jpg]
Reply
#7
Yeah we've tried lowering the rear of the case to allow it to come up closer. The problem is that we're still unable to get everything lined up correctly. We've positioned it several ways on the transmission jack and it seems close but just not close enough I guess. :banghead: We even tried maneuvering it into place w/o the jack. Phew, talk about a workout :rubeyes: I think I can skip weight lifting this week.

I've thought about separating the adaptor section from the case. I even took the bolts loose but the damn thing would not separate. So, I'm going to try and use some long bolts as guides, hoping they can help square everything up.

Round 1 - Bronco 25 Trey 0
Round 2 - Bronco 15 Trey 0

:notworthy:
[SIGPIC][/SIGPIC]
Reply
#8
i wrestled mine in like an aligator.. all in one pc. used cherrypicker to raise it up. run chain through tcase hole in floor. next time i believe i will split mine...
If you can't fix it with a hammer and a welder then your gonna need a new one!
Reply
#9
I've always wrestled it in also - never had a trans jack to use or borrow. I used my floor jack to roll it under and heaved it up and in from there. I have also seen people do just like firefighter recommended and come through the tunnel with a cherry picker. You'll get it and then wonder why in the world it wouldn't go on sooner.
'74 Grocery Getter, '73 Project Buggy, '77 Parts Rig

[Image: Bannerpic.jpg]
Reply
#10
Are we sure this is not a spline alignment issue?
'77 351w- Explorer EFI, 4R70W, 4-link, lockers, 4.56, 35" MT/Rs with a severe rock addiction.Confusedmokin:
Roads? Where we're going, we don't need roads.

[Image: sig2.jpg]
Reply


Possibly Related Threads…
Thread Author Replies Views Last Post
  1996 Ford Bronco- Body Bushing Install jrshepherd 2 2,233 09-19-2018, 02:50 PM
Last Post: blazinchuck
  Adjusting Transfer Case Shifter jdowns67 1 690 10-27-2014, 01:49 PM
Last Post: Bronco Biff
  t-shift t-case won't go into 4-lo scbronco 3 2,176 04-01-2014, 09:54 AM
Last Post: broncosbybart
  what transfer case Ron Burgandy 4 1,557 08-18-2013, 11:06 AM
Last Post: 1st Bronco
  Southern Rods AC kit install..part 1-heater blazinchuck 22 6,185 03-09-2013, 09:47 PM
Last Post: blazinchuck
  ebay radiator(5.0 conversion) install... blazinchuck 8 5,093 10-15-2012, 10:30 PM
Last Post: firefighter2134
  Rattling/clicking noise from Transfer case jdowns67 3 1,115 05-15-2012, 08:03 AM
Last Post: jdowns67
  bushing install ? firefighter2134 2 2,625 08-11-2011, 10:30 PM
Last Post: firefighter2134
  Oil Pressure Guage install location??? Crawdad 3 1,887 04-12-2011, 12:35 PM
Last Post: blazinchuck
  90 Transfer Case Queston 2000F150SAS 0 1,975 03-28-2011, 10:17 AM
Last Post: 2000F150SAS

Forum Jump:


Users browsing this thread: 7 Guest(s)